2003 Chevrolet Astro

Official recalls

• Fuel System, Gasoline

  CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

  Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

  Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

  NHTSA campaign: 06E043000 · 2006-05-19

• Exterior Lighting

  CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

  Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

  Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

  NHTSA campaign: 06E026000 · 2006-03-23

• Suspension

  CERTAIN MINIVANS HAVE AN INTERFERENCE CONDITION BETWEEN THE LOWER BALL JOINT RUBBER BOOT AND THE STEERING KNUCKLE (BOTH LEFT/RIGHT SIDES), WHICH COULD RESULT IN CUTTING OF THE BOOT THAT IS INTENDED TO SEAL THE BALL JOINT. IF THE LOWER BALL JOINT BOOT WERE CUT, CONTAMINATION FROM THE ROAD (SALT, DIRT, WATER, ETC.) COULD ENTER THE BALL SOCKET AREA OF THE BALL JOINT CAUSING THE JOINT TO WEAR OUT TOO QUICKLY.

  Consequence: THE STEERING KNUCKLE COULD SEPARATE FROM THE LOWER CONTROL ARM, DROPPING DOWN THE AFFECTED CORNER OF THE VEHICLE. THE COIL SPRING WOULD PUSH THE CONTROL ARM DOWN INTO CONTACT WITH THE GROUND, CREATING A DRAG THAT WOULD SLOW THE VEHICLE. THE DRIVER COULD HAVE DIFFICULTY IN MAINTAINING THE DIRECTIONAL CONTROL OF THE VEHICLE. IN ADDITION, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE IF FORCES RESULTING FROM THE WHEEL'S DRAGGING ACTION WERE SUFFICIENT TO FRACTURE THE TIE ROD END AND UPPER BALL JOINT CONNECTIONS. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL'S HYDRAULIC BRAKE HOSE, RESULTING IN LOST BRAKING PERFORMANCE FROM THE FRONT BRAKE SYSTEM. VEHICLE STOPPING DISTANCE WOULD INCREASE, WHICH COULD RESULT IN A CRASH.

  Remedy: DEALERS WILL REPLACE THE STEERING KNUCKLES. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 8, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

  NHTSA campaign: 03V328000 · 2003-09-12