2002 GMC Envoy

Official recalls

• Exterior Lighting

  CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NO 335-1120L-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION THE LAMP HOUSING SHAPE DEFORMED DISTORTING THE ASSEMBLY ANGLE OF THE REFLECTOR AND INFLUENCED THE AIMING POSITION. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

  Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

  Remedy: MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON FEBRUARY 16, 2007. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.

  NHTSA campaign: 07E014000 · 2007-02-26

• Engine And Engine Cooling

  SOME SPORT UTILITY VEHICLES EQUIPPED WITH AN ELECTRONICALLY CONTROLLED AIR SUSPENSION (ECAS) HAVE A CONDITION IN WHICH THE ECAS MAY PRODUCE A BRIEF ELECTRICAL SPIKE WHILE THE VEHICLE IS OPERATING. THIS ELECTRICAL SPIKE CAN DISRUPT THE POWERTRAIN CONTROL MODULE (PCM) CAUSING THE VEHICLE TO STALL.

  Consequence: IF THE SPIKE DAMAGES THE PCM, THE VEHICLE MAY NOT RESTART. IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.

  Remedy: DEALERS WILL INSTALL A WIRING HARNESS. THE RECALL WILL BEGIN ON AUGUST 19, 2004. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537 OR GMC AT 1-866-996-9463.

  NHTSA campaign: 04V289000 · 2004-06-23

• Seat Belts

  CERTAIN LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." ONE OF THE TWO SENSORS IN THE DRIVER'S AND FRONT PASSENGER'S SEAT BELT RETRACTORS COULD BE INOPERATIVE. THE SEAT BELT RETRACTORS WILL LOCK WHEN THE BELT WEBBING IS EXTRACTED DURING A CRASH; HOWEVER, THE MECHANISM THAT LOCKS THE SEAT BELT RETRACTOR WHEN THE VEHICLE DECELERATES QUICKLY, SUCH AS HEAVY BRAKING, MAY NOT OPERATE AS INTENDED.

  Consequence: IF THIS WERE TO OCCUR, THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, AND COULD RESULT IN INJURY TO THE OCCUPANT.

  Remedy: DEALERS WILL INSPECT THE DRIVER AND FRONT PASSENGER SAFETY BELT RETRACTORS, AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 24, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537.

  NHTSA campaign: 04V201000 · 2004-04-28

• Visibility

  CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.

  Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

  Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.

  NHTSA campaign: 04V046000 · 2004-02-04