2005 Pontiac Grand Am Se

Official recalls

• Electrical System

  This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

  Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

  Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

  NHTSA campaign: 14V400000 · 2014-07-03

• Exterior Lighting

  SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

  Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

  Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

  NHTSA campaign: 09E012000 · 2009-04-07

• Fuel System, Other

  CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

  Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

  Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

  NHTSA campaign: 07E021000 · 2007-03-12

• Suspension

  CERTAIN PASSENGER VEHICLES EQUIPPED WITH REAR SUSPENSION KNUCKLE BOLTS THAT ARE NOT TO SPECIFICATION AND COULD FRACTURE UNDER HIGH LOADS THAT CAN OCCUR IN SOME DRIVING CONDITIONS.

  Consequence: IF THE BOLT FRACTURE, THE REAR SUSPENSION LINKAGE COULD DETACH FROM THE KNUCKLE AND THE REAR WHEEL WOULD BE ABLE TO TURN INBOARD OR OUTBOARD. SUDDEN CHANGES IN VEHICLE HANDLING COULD OCCUR, PARTICULARLY AT HIGHER SPEEDS, AND THE DRIVER MAY NOT BE ABLE TO CONTROL THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.

  Remedy: DEALERS WILL REPLACE BOTH REAR SUSPENSION KNUCKLE BOLTS FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 9, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

  NHTSA campaign: 05V054000 · 2005-02-14