2006 Volkswagen 2006 Volkswagen Beetle Automobile

Official recalls

• Fuel System, Gasoline

  VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

  Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

  NHTSA campaign: 10V621000

• Equipment

  CERTAIN PASSENGER VEHICLES EQUIPPED WITH 17-INCH WHEELS AND A 2.5L ENGINE FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE PRODUCED WITH A TIRE INFORMATION LABEL THAT LISTS AN INCORRECT FRONT TIRE SIZE. THE CORRECT FRONT TIRE SIZE SHOULD BE LISTED AS 225/45 R17. THE INFLATION PRESSURE IS CORRECT.

  Remedy: OWNERS WILL BE PROVIDED WITH A NEW TIRE INFORMATION LABEL AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.

  NHTSA campaign: 06V043000

• Exterior Lighting

  ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

  Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

  NHTSA campaign: 07V063000

• Service Brakes, Hydraulic

  CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

  Remedy: CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

  NHTSA campaign: 07E023000